本文已被:浏览 1578次 下载 1683次
投稿时间:2018-06-29 修订日期:2018-06-29
投稿时间:2018-06-29 修订日期:2018-06-29
中文摘要: 以两种途径研究了混凝沉淀法对湖南某多金属矿选矿废水COD去除的可行性。用聚合硫酸铁(PFS)、七水硫酸亚铁为水处理剂,分别在总尾矿矿浆和尾矿库出水中考察初始pH,混凝剂种类及药剂用量等因素对选矿废水COD去除的影响。结果表明,在总尾矿矿浆中加入聚合硫酸铁1g/L,COD由186mg/L降至121 mg/L,或在尾矿库出水中控制初始pH为7-9,加入七水硫酸亚铁500mg/L,COD由135mg/L降至88mg/L。以第一种方案进行工业试验,取得了良好指标,排水pH为6-9,COD<100mg/L,达到污水综合排放标准(GB8978-1996)一级标准的要求。
Abstract:Two schemes were used to study the feasibility of coagulation and sedimentation method for COD removal from a mineral processing wastewater from a multi - metal mine in Hunan Province. Polyferric sulfate (PFS) and ferrous sulfate heptahydrate were used as water treatment agents in the total tailings. The effects of initial pH, coagulant types and dosage of pharmaceuticals on COD removal of mineral processing wastewater were investigated. The results showed that the addition of polyferric sulfate was 1g/L, the COD decreased from 186mg/L to 121 mg/L. Or the initial pH in the tailings reservoir was 7-9, adding ferrous sulfate heptahydrate 500mg/L, COD decreased from 135mg/L to 88mg/L. The author uses the first program to carry out the industrial test, and achieved good indicators. The drainage pH was 6-9, COD below 100mg/L. To achieve comprehensive wastewater discharge the first standard requirements.
文章编号: 中图分类号: 文献标志码:
基金项目:“创新驱动计划”(智能化清洁化现代矿业工程理论与技术课题),高等学校学科创新引智计划,湖南省高等学校2011“战略金属矿产资源清洁高效利用”协同创新中心项目对本文的资助。
作者 | 单位 | |
曹学锋 | 中南大学资源加工与生物工程学院 | caoxuefeng64@126.com |
吴江求 | 中南大学资源加工与生物工程学院 | 421690683@qq.com |
孟祥松 | 中南大学资源加工与生物工程学院 | |
孙伟* | 中南大学资源加工与生物工程学院 | sunmenghu@126.com |
引用文本:
曹学锋,吴江求,孟祥松,孙伟.降低湖南某多金属矿选矿废水COD试验研究[J].有色金属(选矿部分),2019(1):.
caoxuefeng,wujiangqiu,mengxiangsong,sunwei.Study on reducing wastewater COD on polymetallic mineral processing plantin Hunan[J].Nonferrous Metals(Mineral Processing Section),2019(1):.
曹学锋,吴江求,孟祥松,孙伟.降低湖南某多金属矿选矿废水COD试验研究[J].有色金属(选矿部分),2019(1):.
caoxuefeng,wujiangqiu,mengxiangsong,sunwei.Study on reducing wastewater COD on polymetallic mineral processing plantin Hunan[J].Nonferrous Metals(Mineral Processing Section),2019(1):.